[1]范育奇,顾智华,张金龙,等.基于叠栅信号的超精密定位特性研究[J].南京师范大学学报(工程技术版),2015,15(04):009.
 Fan Yuqi,Gu Zhihua,Zhang Jinlong,et al.Research on Speciality of Ultra-Precision Alignment Based on Moiré Signals[J].Journal of Nanjing Normal University(Engineering and Technology),2015,15(04):009.
点击复制

基于叠栅信号的超精密定位特性研究
分享到:

南京师范大学学报(工程技术版)[ISSN:1006-6977/CN:61-1281/TN]

卷:
15卷
期数:
2015年04期
页码:
009
栏目:
电气与电子工程
出版日期:
2015-12-20

文章信息/Info

Title:
Research on Speciality of Ultra-Precision Alignment Based on Moiré Signals
作者:
范育奇1顾智华1张金龙1刘京南2内田敬久3
(1. 南京师范大学电气与自动化工程学院,江苏 南京 210042)
(2.东南大学自动化学院,江苏 南京 210096)
(3.日本爱知工业大学智能机械工学科,日本 丰田 470-0392)
Author(s):
Fan Yuqi1Gu Zhihua1Zhang Jinlong1Liu Jingnan2Yoshihisa Uchida3
(1.School of Electrical and Automation Engineering,Nanjing Normal University,Nanjing 210042,China)
(2.School of Automation,Southeast University,Nanjing 210096,China)
(3.Department of Intelligent Machinery Engineering,Aichi Institute of Technology,Toyoda 470-0392,Japan)
关键词:
叠栅信号超精密定位光栅倾斜光栅常数定位精度
Keywords:
Moiré signalultra-precision alignmentgrating tiltedgrating constantposition precision
分类号:
TP932
文献标志码:
A
摘要:
介绍了一种采用叠栅信号实现超精密定位的定位方法,首先建立了衍射叠栅信号和相对位移关系的数学模型,并在MATLAB仿真软件的辅助下完成了对其定位特性的研究. 探讨了光栅倾斜对定位精度的影响,倾斜角越大,定位点的偏移越大,为确保高的定位精度,光栅的倾斜角度必须控制在一定范围之内. 研究发现激光束束径和莫尔信号之间存在一定关系,当激光束直径为光栅常数的11倍及以上时,激光莫尔信号几乎不受外界干扰的影响,此时能够达到更高的定位精度. 同时,分析了不同光栅常数对定位精度、定位行程的影响,并进而提出了粗光栅与细光栅相结合的两段式复合定位技术,可使定位装置在较大的行程范围内实现高精度定位. 实验表明,采用衍射叠栅信号的超精密定位可获得±10 nm的定位精度.
Abstract:
A measure to realize ultra-precision position based on Moiré signal is introduced. Firstly a mathematical model is established with respect to the diffraction double gratings and the relative displacement. And then study is conducted about the characteristics of position by using simulation software. Also the impact about position precision made by grating tilted is discussed. The result indicates that the larger tilt angle is the more anchor point offsets. So tilt angle of grating must be controlled in a certain range so that the higher positioning accuracy can be ensured. The relationship between Moiré signals and the laser beam diameter is studied,and it shows that when the laser beam diameter is 11 times more than the grating constant,the signal of laser stacked gate signals is difficult to be interrupted by interference noise. In this case,higher positioning precision is likely to be easily reached. Addition,the influence that different grating constant made on position accuracy and orientation schedule is analyzed,and then a technology of two-stages compound positioning of coarse and fine grating is raised up,which can make the positioning device realize higher position precision in a larger range. The experimental result shows that the fold grating signal can perform positioning accuracy of ±10 nm.

参考文献/References:

[1] 陈希,楼平,余水宝,等. 基于莫尔条纹的光纤惯性式振动传感器系统[J]. 光电子·激光,2014,25(1):13-19.
CHEN X,LOU P,YU S B,et al. Moiré fringe based fiber optic inertial vibration sensor system[J]. Journal of optoelectronics·laser,2014,25(1):13-19.(in Chinese)
[2] GORDON J A,NOVOTNY D R. Simultaneous imaging and precision alignment of two mm wave antennas based on polarization-selective machine-vision[J]. IEEE transactions on instrumentation and measurement,2012,61(11):3 065-3 071.
[3] ZHANG J L,YANG A K,LIU J N. Study on compound ultra-precision alignment technique[J]. Chinese journal of scientific instrument,2007,28(10):1 741-1 745.
[4] AMTHOR A,ZSCHAECK S,AMENT C. High precision position control using an adaptive friction compensation approach[J]. IEEE transactions on automatic control,2010,55(1):274-278.
[5] 杨川,赵强,张志. 智能控制在超精密定位中的应用研究[J]. 仪器仪表学报,2009(6):1 218-1 223.
YANG C,ZHAO Q,ZHANG Z. Applica tion research on intelligent control system in ultra-precision positioning system[J]. Chinese journal of scientific instrument,2009(6):1 218-1 223.(in Chinese)
[6] SUWADA T,SATOH M,TELADA S,et al. Experimental investigation on focusing characteristics of a He-Ne laser using circular Fresnel zone plate for high-precision alignment of linear accelerators[J]. Review of scientific instruments,2012,83(5):053301.
[7] CONG S,LIANG Y. PID-like neural network nonlinear adaptive control for uncertain multibariable motion control systems[J]. IEEE transactions on industrial electronics,2009,56(10):3 872-3 879.
[8] 朱维斌,朱善安,叶树亮,等. 基于相位跟踪原理的超精密定位平台研究[J]. 仪器仪表学报,2012,33(10):2 301-2?306.
ZHU W B,ZHU S A,YE S L,et al. Research on ultra-precision positioning platform based on phase tracking[J]. Chinese journal of scientific instrument,2012,33(10):2 301-2 306.(in Chinese)
[9] 张金龙,徐慧,刘京南,等. 反射式超精密定位智能控制系统的研究[J]. 光电子·激光,2011,22(8):1 203-1 206.
ZHANG J L,XU H,LIU J N,et al. Research on intelligent control system with reflective ultra-precision positioning[J]. Journal of optoelectronics·laser,2011,22(8):1 203-1 206.(in Chinese)
[10] 王一刚,蒋刚毅,郁梅,等. 基于光照分离模型的显微图像清晰度判定[J]. 光电子·激光,2013,24(11):2 226-2 232.
WANG Y G,JIANG G Y,YU M,et al. A micro-image definition assessment method based on illumination eliminated model[J]. Journal of optoelectronics·laser,2013,24(11):2 226-2 232.(in Chinese)
[11] ZHAO S W,CHEUNG N C,GAN W C,et al. High-precision position control of a linear-switched reluctance motor using a self-tuning regulator[J]. IEEE transactions on power electronics,2010,25(11):2 820-2 827.
[12] 邢德奎,达飞鹏,张虎. 圆形目标精密定位方法的研究与应用[J]. 仪器仪表学报,2009(12):2 593-2 598.
Xing D K,Da F P,Zhang H. Research and application of locating of circular target with high accuracy[J]. Chinese journal of scientific instrument,2009(12):2 593-2 598.(in Chinese)
[13] ZHANG J L,XU H,LIU J N,et al. PID control based on fuzzy neural network for precision angular alignment[J]. Chinese journal of scientific instrument,2012,33(3):549-554.

备注/Memo

备注/Memo:
收稿日期:2014-12-14. 
基金项目:国家“863”计划(2005AA303610)、江苏省自然科学基金(BK2009406). 
通讯联系人:张金龙,教授,研究方向:超精密定位及测量技术. E-mail:zjl0310@163.com
更新日期/Last Update: 2015-12-20