[1]树童,王秦超,卢平,等.生物质热解焦对模拟烟气中汞吸附特性的实验研究[J].南京师范大学学报(工程技术版),2012,12(02):036-42.
 Shu Tong,Wang Qinchao,Lu Ping.Experimental Study of Mercury Adsorption Characteristics of Biomass-pyrolysis Chars in the Simulated Flue Gas[J].Journal of Nanjing Normal University(Engineering and Technology),2012,12(02):036-42.
点击复制

生物质热解焦对模拟烟气中汞吸附特性的实验研究
分享到:

南京师范大学学报(工程技术版)[ISSN:1006-6977/CN:61-1281/TN]

卷:
12卷
期数:
2012年02期
页码:
036-42
栏目:
出版日期:
2012-06-20

文章信息/Info

Title:
Experimental Study of Mercury Adsorption Characteristics of Biomass-pyrolysis Chars in the Simulated Flue Gas
作者:
树童;王秦超;卢平;
南京师范大学能源与机械工程学院,江苏南京210042
Author(s):
Shu TongWang QinchaoLu Ping
School of Energy and Mechanical Engineering,Nanjing Normal University,Nanjing 210042,China
关键词:
生物质热解热解焦吸附特性
Keywords:
biomasspyrolysisbiomass-pyrolysis charmercuryadsorption characteristics
分类号:
X701
摘要:
以桑树枝、核桃壳、麦秆和稻秆4种生物质为原料,利用固定床热解实验台制备不同的生物质热解焦,采用比表面积与孔隙度分析仪测量了生物质热解焦的比表面积及其孔隙结构参数.利用固定床吸附实验装置,研究了生物质种类、热解温度、吸附温度及汞初始浓度等因素对模拟烟气中汞吸附性能的影响.结果表明:(1)在相同的热解和吸附条件下,核桃壳热解焦的吸附效果最好,其次是桑树枝热解焦和麦秆热解焦,稻秆热解焦的吸附效果最差;(2)在热解温度为400℃~800℃范围内,600℃热解温度下所得生物质热解焦的吸附效果最好,400℃热解焦吸附效果最差;(3)在吸附温度为60℃~120℃的实验范围内,随着吸附温度的升高,单位生物质热解焦汞吸附量明显降低;(4)在汞初始浓度13.5~38.1μg/m3范围内,随着汞初始浓度的增加,单位生物质热解焦汞吸附量有所减小.
Abstract:
Different kinds of biomass-pyrolysis chars were prepared from four kinds of biomass named mulberry twig ( MT) ,nut shell ( NS) ,wheat straw ( WS) ,and rice husk ( RH) in a fixed-bed pyrolysis reactor. The specific surface areas and pore structure parameters were measured by a surface area analyzer. The mercury adsorption characteristics of the biomass-pyrolysis chars were carried out in a fixed-bed adsorption reactor. The effects of biomass type,pyrolysis temperature,adsorption temperature and initial mercury concentration on mercury adsorption characteristics were investigated. The results indicated that: ( 1) At the same conditions of pyrolysis and adsorption reaction,the adsorption characteristics of NS char were the best,MT char and WS chars were in middle,and RS char was the worst. ( 2) At the pyrolysis temperatures of 400℃ ~ 600℃,biomass chars pyrolyzed at 600℃ showed the best adsorption characteristics,and biomass chars pyrolyzed at 400℃ performed the worst adsorption characteristics. ( 3) The unit mercury adsorption capacity of biomass-pyrolysis chars decreased with increasing the adsorption temperature significantly at the adsorption temperature of 60℃ ~ 120℃. ( 4) The unit adsorption capacity of biomass-pyrolysis chars decreased slightly with increasing initial mercury concentration at the initial mercury concentration of 13. 5 μg /m3 ~ 38. 1 μg /m3

参考文献/References:

[1]吴创之,周肇秋,阴秀丽,等. 我国生物质能源发展现状与思考[J]. 农业机械学报,2009,40( 1) : 91-99. Wu Chuangzhi,Zhou Zhaoqiu,Yin Xiuli,et al. Current status of biomass energy development in China[J]. Transactions of the Chinese Society for Agricultural Machinery,2009,40( 1) : 91-99. ( in Chinese)
[2]Senneca O. Kinetics of pyrolysis,combustion and gasification of three biomass fuels[J]. Fuel Processing Technology,2007, 88( 1) : 87-97.
[3]Arias B,Pevida C,Fermoso J,et al. Influence of torrefaction on the grindability and reactivity of woody biomass[J]. Fuel Processing Technology,2008,89( 2) : 169-175.
[4]Liu W,Zeng F,Jiang H,et al. Preparation of high adsorption capacity bio-chars from waste biomass[J]. Bioresource Technology, 2011,102( 17) : 8 247-8 252.
[5]Biagini E,Simone M,Tognotti L. Characterization of high heating rate chars of biomass fuels[J]. Proceedings of the Combustion Institute,2009,32( 2) : 2 043-2 050.
[6]Schroder E,Thomauske K,Weber C,et al. Experiments on the generation of activated carbon from biomass[J]. J Anal Appl Pyrolysis,2007,79( 1-2) : 106-111.
[7]任建莉,周劲松,骆仲泱,等. 活性碳吸附烟气中气态汞的试验研究[J]. 中国电机工程学报,2004,24( 2) : 171-175. Ren Jianli,Zhou Jinsong,Luo Zhongyang,et al. Experimental study on the adsorption characteristics of mercury by activated carbon[J]. Proceeding of the CSEE,2004,24( 2) : 171-175.
[8]王军辉. 活性炭吸附脱除燃煤中汞的研究[D]. 杭州: 浙江大学环境与资源学院, 2006: 24-25. Wang Junhui. Experimental study on the mercury adsorption by activated carbon from coal[D]. Hangzhou: Zhejiang University, School of Environmental and Resource,2006: 24-25. ( in Chinese)
[9]刘杨先,张军,盛昌栋,等. 燃煤烟气脱汞吸附剂最新研究进展[J]. 现代化工,2008,28( 11) : 19-23. Liu Yangxian,Zhang Jun,Sheng Changdong,et al. New research progress in sorbents for removal of mercury in coal fired flue gas[J]. Modern Chemical Industry,2008,28( 11) : 19-23. ( in Chinese)
[10]张军,林晓芬,印佳敏,等. 生物质焦脱硫性能实验研究[J]. 工程热物理学报,2005,26( 3) : 537-539. Zhang Jun,Lin Xiaofen,Yin Jiamin,et al. Experimental research on the desulphurization performance of biomass char[J]. J of Engineering Thermophysics,2005,26( 3) : 537-539. ( in Chinese)
[11]Dong L,Gao S,Song W,et al. Experimental study of NO reduction over biomass char[J]. Fuel Processing Technology, 2007,88( 7) : 707-715.
[12]陆飞. 生物质焦吸附模拟烟气中SO2 /NO 特性的实验研究[D]. 南京: 南京师范大学能源与机械工程学院,2011: 43- 62. Lu Fei. Experimental study on the adsorption characteristics of SO2 /NO by biomass chars[D]. Nanjing,Nanjing Normal University, School of Energy and Mechanical Engineering,2011: 43-62. ( in Chinese) [13]Olson E S,Miller S J,Sharma R K,et al. Catalytic effects of carbon sorbents for mercury capture[J]. Journal of Hazardous Materials,2000,74( 1 /2) : 61-79.

相似文献/References:

[1]刘巍,杨松祥,王守芳,等.粮油产品的流化加工研究[J].南京师范大学学报(工程技术版),2011,11(01):080.
 Liu Wei,Yang Songxiang,Wang Shoufang,et al.Study on Fluidization Processing of Grain and Oil Product[J].Journal of Nanjing Normal University(Engineering and Technology),2011,11(02):080.
[2]周雷宇,王萌,吴昊,等.操作参数对生物质热解液化及焦炭特征的影响[J].南京师范大学学报(工程技术版),2011,11(04):029.
 Zhou Leiyu,Wang Meng,Wu Hao,et al.Impact of Operation Factors on Biomass Pyrolysis and the Characteristics of Bio-Char[J].Journal of Nanjing Normal University(Engineering and Technology),2011,11(02):029.

备注/Memo

备注/Memo:
基金项目: 国家自然科学基金( 51076067) 、江苏省自然科学基金( BK2010081) .通讯联系人: 卢平,教授,研究方向: 能源清洁利用与污染物控制的研究. E-mail: luping@ njnu. edu. cn
更新日期/Last Update: 2013-03-11